![Engine failure causes fire on another towing vessel says NTSB report](https://iims-media-library.s3.eu-west-2.amazonaws.com/wp-content/uploads/2021/02/12130553/city-of-cleveland.jpg)
The National Transportation Safety Board (NTSB) has released an investigation report on the engine room fire aboard the towing vessel City of Cleveland on the Lower Mississippi River in February 2020. The investigation has identified that catastrophic engine failure caused fire along with crankcase breach of the port main engine.
On 26 February 2020, the towing vessel City of Cleveland was pushing 18 dry cargo barges (15 loaded and 3 empty) upbound on the Lower Mississippi River, approximately 15 miles south of Natchez, Mississippi, when the vessel experienced a main engine failure followed by an engine room fire. All nine crew members safely evacuated to the barges and were rescued by nearby Good Samaritan vessels, which worked to extinguish the fire. The City of Cleveland was later towed to the operator’s facility in Rosedale, Mississippi. There was no pollution or injuries. Damage to the vessel was estimated at $2 million.
Probable cause
The NTSB says the probable cause of the fire aboard the towing vessel City of Cleveland was the catastrophic failure and crankcase breach of the port main engine, resulting from the failure of a connecting rod assembly. Contributing to the severity of damage to the vessel was the lack of a fixed fire-extinguishing system for the engine room, as well as the loss of electrical power to the single fire pump.
Analysis
During an examination of the wreckage, the no. 4 left and right cylinder master connecting and articulating rods were found still attached to each other outside the crankcase, and the piston pin and connecting rod clamp were missing. Therefore, the initial failure was likely with the connecting rod clamp or the bolt that held the piston pin. Regardless, the force of the driven loose connecting rods inside the engine was enough to puncture a hole in the side of the crankcase on the port side and eject the piston head through the no. 4 right cover on the starboard side.
The failure of the connecting rod and subsequent catastrophic damage to the crankcase likely allowed hot pressurized fuel and oil to spread to the lower engine room and thereby ignite. The significant heat and smoke damage to the upper engine room indicated that the fire spread up the port side of the engine room, then aft in the upper engine room, and eventually to the rudder room.
Although the doors to the engine room were closed, the exterior windows in the upper engine room were open, and there were no means for the crew to close them from outside of the engine room. The air drawn through the open windows likely further exacerbated the fire’s spread.
In addition, the vessel’s firehoses were accessible, but the crew could not use them because the running generator in the upper engine room was starved of combustion air and shut down, and the vessel lost electrical power, rendering the single fire pump inoperable. Therefore, the two semi-portable extinguishers, stowed on each side of the upper engine room, were the only means for the crew to fight the conflagration.
The crew had previously performed fire drills aboard the City of Cleveland and planned to fight a possible engine fire by dropping the semi-portable extinguisher hoses and nozzles to the lower engine room and releasing the extinguishers’ dry chemical. However, the portside extinguisher was inaccessible due to the flames, and the hose on the starboard extinguisher failed proximate to the extinguisher.
Additionally, given that the fire was largely fueled by flammable liquids, initially outboard of the port engine and well forward of where the extinguishers were stowed, it is unlikely the crew’s initial plan to use the extinguishers would have succeeded.
The engine room was not equipped with a fixed fire-extinguishing system, nor was it required to be by existing regulations. If the City of Cleveland had a fixed fire-extinguishing system in the engine room, as well as a means to close the ventilation and open windows in the engine room from the outside, the fire may have been able to be extinguished.
Without an effective means to fight the fire, the crew was forced to evacuate to their tow before being picked up and rescued by a nearby Good Samaritan vessel.
Lessons learned
This report follows closely on the heels of another NTSB report into the investigationn into a fire and explosion onboard the towing vessel ‘Susan Lynn’, off Lousiana, in October 2019, also identifying catastrophic engine failure as key cause of the accident.
Engine rooms contain multiple fuel and ignition sources, making the spaces especially vulnerable to rapidly spreading fires.
Designers and operators of towing vessels should evaluate fire hazards and provide effective means to mitigate them. Operators should have equipment and procedures in place to quickly contain and suppress engine room fires before they can spread to other spaces and/or cause a loss of propulsion and electrical power.
Download the full report: NTSB-Engine-Room-Fire-aboard-Towing-Vessel-City-of-Cleveland